Early Valiant Barracuda Club home page

Trouble-shooting with a vacuum gauge!

No. 1. An engine in good condition should have a gauge reading of 17 to 21 and hand should be steady. Also study illustrations Nos. 10 and 11.

No. 2. When opening and closing the throttle quickly the gauge reading on an engine in good condition should drop to 2 and com back to 25.

No. 3. A reading lower than normal and ith the hand steady indicates that rings are in poor condition.

No. 4. Poor adjustment of the carburetor will cause the needle to float slowly between 12 and 16. See also illustration 12.

No. 5. When the hand drops occasionally from 3 to 5 points, from the normal reading, it generally indicates a sticking valve.

No. 6. A burned valve will cause the needle to drop back several divisions each time that particular cylinder operates.

No. 7. Leaking valves also show up on the gauge by the needle dropping back 3 or 4 divisions, whenever that valve opens.

No. 8. When needle has a fast vibration between appoximately 14 and 19 it indicates loose valve guides.

No. 9. A steady reading below 5 indicates a leaky manifold, manifold gasket or carburetor gasket. Also check heat riser.

No. 10. When gauge needle is steady at about 8 to 14 it generally indicates incorrect valve timing. See also illustrations 3, and 11.

No. 11. A reading of 13 to 16 generally indicates incorrect ignition timing. See also illustrations 3, and 10.

No. 12. When needle drifts slowly between 14 and 16 it generally indicates that plug gaps are too close, or breaker points are not properly synchronized.

No. 13. Wide variations of needle increasing with motor speed indicates weak, or broken valve springs.

No. 14. Normal reading at start, but gradually drops, indicates choked muffler.

No. 15. Occasional drop as cylinder is firing may denote valve open or plug not firing.

No. 16. If normal is 20 inches and needle should go to approx 14 check timing. Spark may be retarded.

  No. 17. This action usually indicates a leaky head gasket.  

 

credits: This wonderful page was adapted for HTML from a booklet entitled How To Double The Performance Of Your Car, by Vincent Lombardi, published in 1963 by the Executive Research Institute. Mr. Lombardi is listed as the Vice President of the Society of Automotive Service Managers. Permission to reprint would be sought, if we could locate either the author or publisher. Can anyone assist? Please email the Webmaster. Thanks!